• Rasool Sharifi and Mohammad Ebrahimi.
• Department of Electrical and Computer Engineering, Isfahan University of Technology, Isfahan, Iran. r.sharifi@ec.iut.ac.ir
• ISA Trans. 2011 Jan 1; 50 (1): 14-20.

AbstractThe objective of this paper is to propose a new method for the detection of inter-turn short circuits in the stator windings of induction motors. In the previous reported methods, the supply voltage unbalance was the major difficulty, and this was solved mostly based on the sequence component impedance or current which are difficult to implement. Some other methods essentially are included in the offline methods. The proposed method is based on the motor current signature analysis and utilizes three phase current spectra to overcome the mentioned problem. Simulation results indicate that under healthy conditions, the rotor slot harmonics have the same magnitude in three phase currents, while under even 1 turn (0.3%) short circuit condition they differ from each other. Although the magnitude of these harmonics depends on the level of unbalanced voltage, they have the same magnitude in three phases in these conditions. Experiments performed under various load, fault, and supply voltage conditions validate the simulation results and demonstrate the effectiveness of the proposed technique. It is shown that the detection of resistive slight short circuits, without sensitivity to supply voltage unbalance is possible.Copyright © 2010 ISA. Published by Elsevier Ltd. All rights reserved.

5 keywords...

hide…